material safety data sheet - Applied Industrial Technologies
Transcription
material safety data sheet - Applied Industrial Technologies
MATERIAL SAFETY DATA SHEET UZ Engineered Products 3325 St. Clair Avenue, Cleveland, Ohio 44114 (216) 861-6363 UZ Engineered Products. 145 Adelaide St. S., London, ON N5Z 3K7 (866)-641-5669 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Product Name: Product Description: STRIP AID Anti-slip gel for damaged fasteners. 24 Hour Emergency CHEMTREC Number: MSDS Number: 800-424-9300 700494 2. COMPOSITION/INFORMATION ON INGREDIENTS This product contains no hazardous ingredients as defined by the OSHA Hazard Communications Standard 28CFR1910.1200 3. HAZARDS IDENTIFICATION ***EMERGENCY OVERVIEW*** May cause eye and skin irritation. POTENTIAL HEALTH EFFECTS Eye Contact: Skin Contact: Inhalation: Ingestion: May cause eye irritation. May cause skin irritation. None expected. May cause gastro-intestinal disturbances. 4. FIRST AID MEASURES Eye Contact: Skin Contact: Inhalation: Ingestion: Promptly flush with a large amount of water for at least 15 minutes. If irritation persists, consult a physician. Promptly wash with soap and water and rinse thoroughly. Remove contaminated clothing and launder before reuse. Remove to fresh air. Restore breathing if necessary. If irritation persists, consult a physician. Treat symptomatically. Never give anything to an unconscious person. Contact a physician immediately. 5. FIRE FIGHTING MEASURES Flashpoint: Lower Explosive Limit(LEL): Autoignition Temperature: Flammable Properties: Extinguishing Media: Fire Fighting Instructions: None. NA Upper Explosive Limit(UEL): NA NA None expected. Carbon Dioxide foam, dry chemical, water fog. Wear self-contained breathing apparatus and full protective clothing. 6. ACCIDENTAL RELEASE MEASURES Ventilate area. Use absorbent to pick up residue and dispose of properly. Dispose of in accordance with all Federal, State and Local Regulations regarding waste disposal. 7. HANDLING AND STORAGE This product is for industrial use only. Wash thoroughly after handling. Avoid contact with eyes and skin. Keep out of reach of children. Keep from freezing. Store in a well-ventilated, cool, dry area. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Engineering Controls: Local exhaust preferable. General exhaust acceptable if the exposure to materials is maintained below applicable exposure limits. Personal Protective Equipment: Respiratory: If personal exposure cannot be controlled below applicable limits by ventilation, wear a properly fitted NIOSH-approved organic vapor/particulate respirator. Eye: Wear approved safety glasses or goggles with unperforated sideshields. Skin: None required for normal use where minimal skin contact is expected. For long or repeated contact, wear chemically impervious gloves. Other: An emergency eyewash station or source of clean potable water should be available in case of accidental eye contact. 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance: Physical State: Vapor Pressure @ 20 C: Boiling Point: Solubility in Water: Density: Percent Volatile: Grey. Gel. 18 mm Hg 212 F [100 C] Appreciable. 10.3 lbs/gal [1.2 kg/L] NA Odor: pH: Vapor Density (air = 1): Freezing/Melting Point: Specific Gravity (water = 1): VOC Content: Reactivity in Water: 10. STABILITY AND REACTIVITY Stability: Hazardous Polymerization: Conditions to Avoid: Incompatibility: Hazardous Decomposition Products: Stable. Will not occur. None expected. None expected. Carbon Monoxide, Carbon Dioxide. 11. TOXICOLOGICAL INFORMATION IARC / NTP / OSHA: This product contains no ingredients at 0.1% or greater that is listed as a human carcinogen. 12. ECOLOGICAL INFORMATION NA Mild. NA 0.6 NA 1.24 NA Slower. 13. DISPOSAL CONSIDERATIONS Dispose of in accordance with all Federal, State and Local Regulations regarding pollution and waste disposal. Product as supplied does not contain any hazardous waste. 14. TRANSPORT INFORMATION DOT Shipping Data: Canadian TDG: Not Regulated. Not Regulated. 15. REGULATORY INFORMATION TSCA: CEPA: SARA 313: All ingredients in this product are listed or exempt from listing on the TSCA Chemical Inventory. All ingredients in this product are listed or exempt from listing on the Canadian DSL/NDSL. This product contains no toxic chemicals subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 372). HMIS Classification: Health = 1 Flammability = 0 Reactivity = 0 Personal Protection = B WHMIS Classification: Not Regulated. 16. OTHER INFORMATION NA = Not Available or Not Applicable Read and follow all label directions and precautions before using the product. These products are intended for industrial and institutional use only. NOT FOR HOUSEHOLD USE OR RESALE. KEEP OUT OF THE REACH OF CHILDREN. While we believe that the data contained herein is factual and the opinion expressed are those of qualified experts, the data are not to be taken as a warranty or representation for which the company assumes legal responsibility. They are offered solely for your consideration, investigation, and verification. Any use of these data and information must be determined by the user to be in accordance with applicable Federal, State, and Local Laws and regulations. HEALTH AND SAFETY INFORMATION: (216) 861-6363 Prepared On: May 2012 Replaces: May 2009 Completed By: Regulatory Affairs FICHE SIGNALÉTIQUE UZ Engineered Products 3325 St. Clair Avenue, Cleveland, OH 44114 États-Unis (216) 861-6363 UZ Engineered Products 145 Adelaide St. S., London, ON N5Z 3K7 (866)-641-5669 1. IDENTIFICATION DU PRODUIT CHIMIQUE ET DE LA SOCIÉTÉ Nom du produit : STRIP AID Description du produit : gel agrippant pour visserie endommagée Numéro d’urgence CHEMTREC 24 h/24 : Numéro de fiche signalétique : 800-424-9300 700494 2. COMPOSITION/INFORMATION SUR LES INGRÉDIENTS Ce produit ne contient aucun ingrédient défini comme étant dangereux par la norme sur les communications relatives aux matières dangereuses de l’OSHA 28CFR1910.1200. 3. IDENTIFICATION DES DANGERS ***SITUATIONS D’URGENCE*** Peut causer une irritation de l'œil et de la peau. EFFETS POSSIBLES SUR LA SANTÉ Contact oculaire : Contact cutané : Inhalation : Ingestion : Peut causer une irritation de l'œil. Peut causer une irritation de la peau. Aucun effet présumé. Peut causer des troubles gastro-intestinaux. 4. PREMIERS SOINS Contact oculaire : Contact cutané : Inhalation : Ingestion : Rincer rapidement à grande eau pendant 15 minutes au minimum. Si l'irritation persiste, consulter un médecin. Laver rapidement la peau à l’eau et au savon et rincer avec soin. Enlever les vêtements contaminés et les laver avant réutilisation. Faire sortir la victime à l’air frais. Le cas échéant, rétablir la respiration. Si l'irritation persiste, consulter un médecin. Traiter les symptômes. Ne jamais rien administrer à une personne inconsciente. Contacter un médecin immédiatement. 5. EN CAS D’INCENDIE Point d'éclair : Limite d'explosivité inférieure (LEL) : Température d’auto-inflammation : Propriétés d’inflammabilité : Moyens d’extinction : Lutte contre l’incendie : néant néant Limite d'explosivité supérieure (UEL) : néant néant aucune présumée Mousse de dioxyde de carbone, poudre chimique, brouillard d'eau. Porter un appareil respiratoire autonome et une tenue protectrice intégrale. 6. ÉMISSIONS ACCIDENTELLES Ventiler la zone. Utiliser un matériau absorbant pour récupérer le résidu et éliminer de façon appropriée. Éliminer conformément à toutes les réglementations fédérales, provinciales et locales en vigueur en matière d'élimination des déchets. 7. MANUTENTION ET ENTREPOSAGE Ce produit est destiné à un usage industriel uniquement. Se laver avec soin après manipulation. Éviter tout contact avec les yeux et la peau. Garder hors de la portée des enfants. Garder à l'abri du gel. Entreposer dans un endroit frais, sec et bien ventilé. 8. CONTRÔLE DE L’EXPOSITION / PROTECTION PERSONNELLE Moyens techniques : Ventilation aspirante locale conseillée. Une ventilation aspirante générale est acceptable si l'exposition aux substances est maintenue en dessous des limites d'exposition réglementaires. Équipement de protection individuelle : respiratoire : Si la ventilation ne permet pas de maintenir l'exposition individuelle en dessous des limites réglementaires, prévoir le port d'un appareil respiratoire pour particules et vapeurs organiques agréé NIOSH. oculaire : Porter des lunettes de sécurité à écrans latéraux non perforés. cutanée : Aucune protection requise pour un emploi normal susceptible de produire un contact cutané minimal. En cas de contact prolongé ou répété, porter des gants de protection chimique. autre : Une station d'eyewash de secours ou une source de l'eau potable propre devrait être disponible en cas de contact d'oeil accidentel. 9. PROPRIÉTÉS PHYSIQUES ET CHIMIQUES Aspect : État physique : Tension de vapeur à 20°C : Point d’ébullition : Solubilité dans l’eau : Masse volumique : Pourcentage de matières volatiles : gris gel 18 mm Hg 100 C notable 1236 g/l néant Odeur : légère pH : néant Densité de la vapeur (air = 1) : 0,6 Point de congélation/fusion : néant Densité (eau = 1) : 1,24 Teneur en composés organiques volatils : néant Réactivité dans l’eau : plus lente 10. STABILITÉ ET RÉACTIVITÉ Stabilité : Polymérisation dangereuse : Conditions à éviter : Incompatibilité : Produits de décomposition dangereux : stable. ne se produit pas. aucune présumée. aucune présumée. monoxyde de carbone, dioxyde de carbone. 11. INFORMATIONS TOXICOLOGIQUES CIRC / NTP / OSHA : Ce produit ne contient aucun ingrédient déclaré cancérogène humain à des teneurs supérieures ou égales à 0,1%. 12. INFORMATIONS ÉCOLOGIQUES néant 13. ÉLIMINATION Éliminer conformément à toutes les réglementations fédérales, provinciales et locales en matière d’environnement et d'élimination des déchets. Le produit tel qu’il est fourni ne contient aucun déchet dangereux. 14. TRANSPORT Données D.O.T.: TMD (Canada) : non réglementé. non réglementé. 15. INFORMATIONS RÉGLEMENTAIRES TSCA : LCPE (Canada) : SARA 313 : Tous les ingrédients de ce produit figurent ou sont dispensés de figurer sur l’inventaire du TSCA. Tous les ingrédients de ce produit figurent ou sont dispensés de figurer sur les LIS/LES (Canada). Ne produit ne contient aucune substance chimique toxique devant être déclarée aux termes de la section 313 de la loi Emergency Planning and Community Right-ToKnow Act de 1986 (40 CFR 372). Classification HMIS : Santé = 1 Classification SIMDUT : non réglementé. Inflammabilité = 0 Réactivité = 0 Protection individuelle = B 16. AUTRES INFORMATIONS néant = non disponible ou sans objet Lire et suivre toutes les instructions et les précautions d’emploi figurant sur l’étiquette avant d’utiliser le produit. Ces produits sont destinés à l’industrie et aux collectivités uniquement. CES PRODUITS NE SONT PAS DESTINÉS À UN USAGE DOMESTIQUE OU À LA REVENTE. CONSERVER HORS DE LA PORTÉE DES ENFANTS. Bien que les informations ci-dessus soient jugées exactes et que les avis exprimés soient ceux d’experts qualifiés, les données fournies ne tiennent pas lieu de garantie ou de déclaration engageant la responsabilité juridique de la société. Ces informations sont fournies à des fins d’examen, de recherche et de vérification. L’utilisation de ces informations sera déterminée par l’utilisateur, conformément aux lois et réglementations fédérales, provinciales et locales en vigueur. INFORMATIONS SUR LA SANTÉ ET LA SÉCURITÉ : (216) 861-6363 Date de Préparation : Mai 2012 Remplace Mai 2009 Par : Affaires réglementaires