PDF zu diesem Artikel ansehen
Transcription
PDF zu diesem Artikel ansehen
Page : 1 / 9 MATERIAL SAFETY DATA SHEET Version : 1 Date : 11 / 7 / 2012 Supersedes : 0 / 0 / 0 Tipp-ex® Shake’n Choose Correction pen BIC SECTION 1 IDENTIFICATION OF THE SUBSTANCE/MIXTURE AND OF THE COMPANY/UNDERTAKING 1.1. Product identifier 1.2. Relevant identified uses of the substance or mixture and uses advised against 1.3. Details of the supplier of the safety data sheet Name Address Telephone number Telefax number E-mail 1.4. Emergency telephone number : Tipp-ex® Shake’n Choose Correction pen : Correction fluid : SOCIETE BIC : 14, Rue Jeanne d'Asnières 92611 CLICHY Cédex FRANCE : + 33 01 45 19 52 00 : +33 01 45 19 52 99 : [email protected] : ORFILA (France) : +33 1 45 42 59 59 SECTION 2 HAZARDS IDENTIFICATION 2.1. Classification of the substance or mixture MOST IMPORTANT HAZARDS Adverse human health effects Environmental effects Physical and chemical hazards - Fire or explosion Classification of the product : May cause drowsiness or dizziness. Causes skin irritation. : Toxic to aquatic life with long lasting effects. : Highly flammable liquid and vapour. May form flammable/explosive vapour-air mixtures : According to European regulations (67/548/EEC & 1999/45/EC), this product is classified as : F; R11 Xi; R38 R67 N; R51/53 According to CLP regulation, this product is classified as : Flam. Liq.2 H225 Skin Irrit.2 H315 STOT SE 3 H336 Aquatic Chronic 2 H411 2.2. Label elements • Hazard pictograms • Signal words : Danger SOCIETE BIC 14, Rue Jeanne d'Asnières 92611 CLICHY FRANCE Page : 2 / 9 MATERIAL SAFETY DATA SHEET Version : 1 Date : 11 / 7 / 2012 Supersedes : 0 / 0 / 0 Tipp-ex® Shake’n Choose Correction pen BIC SECTION 2 HAZARDS IDENTIFICATION (continued) : H225 : Highly flammable liquid and vapour H315 : Causes skin irritation H336 : May cause drowsiness or dizziness H411 : Toxic to aquatic life with long lasting effects : P102 : Keep out of reach of children P210 : Keep away from heat/sparks/open flames/hot surfaces. - No smoking. P273 : Avoid release to the environment P302+P352 : IF ON SKIN: Wash with plenty of soap and water : None, to our knowledge • Hazard statements • Precautionary statements 2.3. Other hazards SECTION 3 COMPOSITION / INFORMATION ON INGREDIENTS MIXTURE Chemical nature Hazardous constituents : Mixture of solvents and titanium dioxide Substance name Titanium dioxide : Contents < 50 % CAS No 13463-67-7 EC No 236-675-5 Index No ----- ----- ------------------------------------------------ Naphtha (petroleum), hydrotreated light : < 30 % 64742-49-0 265-151-9 649-328-00-1 ----- F; R11 Xn; R65 R67 Xi; R38 N; R51-53 -----------------------------------------------Flam. Liq. 2 H225 Asp. Tox 1 H304 Skin Irrit. 2 H315 STOT SE 3 H336 Aquatic Chronic 2 H411 Naphtha (petroleum), light alkylate : < 30 % 64741-66-8 265-068-8 649-276-00-X ----- F; R11 Xn; R65 R67 Xi; R38 N; R51-53 -----------------------------------------------Flam. Liq. 2 H225 Asp. Tox 1 H304 Skin Irrit. 2 H315 STOT SE 3 H336 Aquatic Chronic 2 H411 Further information Classification : Full text of R and H phrases : see section 16 SECTION 4 FIRST AID MEASURES 4.1. Description of first aid measures : Move the affected person away from the contaminated area and into the fresh air Inhalation If the person feels unwell : Call a doctor : Wash immediately with plenty of soap and water Skin contact In case of redness or irritation, consult a doctor : Immediately rinse with water for a prolonged period while holding the eyes wide Eye contact open If irritation persists, consult an eye specialist : Never attempt to induce vomiting Ingestion Consult a doctor SOCIETE BIC 14, Rue Jeanne d'Asnières 92611 CLICHY FRANCE Page : 3 / 9 MATERIAL SAFETY DATA SHEET Version : 1 Date : 11 / 7 / 2012 Supersedes : 0 / 0 / 0 Tipp-ex® Shake’n Choose Correction pen BIC SECTION 4 FIRST AID MEASURES (continued) 4.2. Most important symptoms and effects, both acute and delayed 4.3. Indication of any immediate medical attention and special treatment needed : In case of contact with skin : Redness, pain. On inhalation : Drowsiness , Dizziness : No information available SECTION 5 FIRE-FIGHTING MEASURES : Foam Powders Carbon dioxide (CO2) 5.2. Special hazards arising from the : The vapours are heavier than air and may travel along the ground. Distance ignition possible. substance or mixture On heating or during combustion : Toxic vapors may be released : Clear the danger area 5.3. Advice for fire-fighters Cool down the containers/equipment exposed to heat with a water spray Contain the extinguishing fluids by bunding (the product is hazardous for the environment) Do not attempt to fight the fire without suitable protective equipment : Standard protection Self-contained breathing apparatus 5.1. Extinguishing media SECTION 6 ACCIDENTAL RELEASE MEASURES 6.1. Personal precautions, protective : For non-emergency personnel : Avoid contact with skin and eyes equipment and emergency Do not breathe vapours procedures No flames, no sparks. Eliminate all sources of ignition. Do not smoke Mark out the contaminated area with signs and prevent access to unauthorized personnel For emergency responders : In case of important spillage : Do not attempt to fight the fire without suitable protective equipment Protective equipment : - full protective clothing and equipment - respiratory protective device Stop the leak as quickly as possible (using non-sparking tools) Prevent the product from entering drains (risk of explosion) Ventilate spillage area : Contain the spilled material by bunding (product is hazardous for the environment) 6.2 Environmental precautions Do not discharge into drains and rivers Methods for cleaning up : : Recover the product by mechanical means. - Recovery : Absorb non-recoverable liquid with: - Neutralization : - inert absorbent material - earth or sand SOCIETE BIC 14, Rue Jeanne d'Asnières 92611 CLICHY FRANCE Page : 4 / 9 MATERIAL SAFETY DATA SHEET Version : 1 Date : 11 / 7 / 2012 Supersedes : 0 / 0 / 0 Tipp-ex® Shake’n Choose Correction pen BIC SECTION 6 ACCIDENTAL RELEASE MEASURES (continued) - Disposal 6.4 Reference to other sections : Dispose of contaminated materials in accordance with current regulations : For further information see section 13 SECTION 7 HANDLING AND STORAGE 7.1. Precautions for safe handling Technical measures Precautions Hygiene measures 7.2. Conditions for safe storage, including any incompatibilities Technical measures Storage conditions - Recommended Incompatible materials Packaging materials - Recommended 7.3. Specific end use(s) : Vapour extraction at source Use non-sparking tools : Avoid contact with skin and eyes Avoid the build-up of electrostatic charge Smoking is forbidden Do not overheat the product. : Do not drink, eat or smoke in the workplace Always wash your hands after handling the product : The floor of the depot must be impermeable, non-combustible and designed to form a basin, in order that stored flammable liquids should not, under any circumstances, be released outside : Store : - in a cool and dry area - in a well-ventilated area - the container tightly closed - away from any source of ignition - away from heat - away from any flames : Strong oxidizing agents Oxidizing materials : Original packaging : No information available SECTION 8 EXPOSURE CONTROLS / PERSONAL PROTECTION 8.1. Control parameters Occupational exposure limits - France - Germany : Titanium dioxide : VME : 10 mg/m³ (Ti) Hydrocarbons C6 - C12 : VME : 1000 mg/m³ VLE : 1500 mg/m³ : None SOCIETE BIC 14, Rue Jeanne d'Asnières 92611 CLICHY FRANCE Page : 5 / 9 MATERIAL SAFETY DATA SHEET Version : 1 Date : 11 / 7 / 2012 Supersedes : 0 / 0 / 0 Tipp-ex® Shake’n Choose Correction pen BIC SECTION 8 EXPOSURE CONTROLS / PERSONAL PROTECTION (continued) 8.2. Exposure controls Engineering measures Personal protective equipment - Respiratory protection - Hand protection - Eye protection : Ensure good ventilation of the work station Extraction to remove vapours at their source : If vapour is released: Aerosol filter type A : Impermeable protective gloves The protective gloves to be used must comply with the specifications of EC directive 89/686/EEC and the resultant standard EN 374 Breakthrough time : refer to the recommandations of the gloves supplier : Safety goggles SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on basic physical and chemical properties Physical state Colour Odour Odour threshold pH Specific temperatures - Boiling - Melting point Decomposition temperature Flammability characteristics - Flash point - Auto-ignition temperature Oxidizing properties Explosive limits in air : - Lower : - Upper : Vapour pressure Vapour density (air = 1) Relative density (water = 1) Solubility - in water Octanol/water partition coefficient Kinematic viscosity Volatile component : : : : : : Liquid white solvent. Not determined Not applicable : 95-114 °C (760 mmHg) : Not determined : Not determined : -4.5 °C (NF EN ISO 13736) : Not determined : Non oxidizing material according to EC criteria : : : : : 1.7 % (volume) 12.3 % (volume) 26-49 mmHg (20 °C) Not determined 1.25 (25 °C) : : : : Practically insoluble. (0.1 g/l) Not determined > 60 mm²/s (40 °C) 0.89 - 1.08 % SOCIETE BIC 14, Rue Jeanne d'Asnières 92611 CLICHY FRANCE Page : 6 / 9 MATERIAL SAFETY DATA SHEET Version : 1 Date : 11 / 7 / 2012 Supersedes : 0 / 0 / 0 Tipp-ex® Shake’n Choose Correction pen BIC SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES (continued) Evaporation rate 9.2 Other information : Not determined : No information available SECTION 10 STABILITY AND REACTIVITY 10.1. Reactivity 10.2. Chemical stability 10.3. Possibility of hazardous reactions 10.4. Conditions to avoid 10.5. Incompatible materials 10.6. Hazardous decomposition products : To our knowledge, the product does not present any particular risk : Stable at ambient temperature and under normal conditions of use : May form flammable/explosive vapour-air mixtures : Heat, sparks, open flames, ignition source : - strong oxidizing agents - strong reducing agents : On combustion or on thermal decomposition (pyrolysis) releases : Carbon oxides (CO, CO2) Various hydrocarbon fragments SECTION 11TOXICOLOGICAL INFORMATION 11.1. Information on toxicological effects Acute toxicity Skin corrosion/irritation Serious eye damage/irritation Respiratory or skin sensitization Carcinogenicity Germ cell mutagenicity Reproductive toxicity STOT - single exposure : Based on available data, the classification criteria are not met. Naphtha (petroleum), light alkylate : LC 50 inhalation / 4h (rat) : > 5.04 ppm LD 50 oral (rat) : > 7000 mg/kg LD 50 skin (Rabbit) : > 2000 mg/kg Naphtha (petroleum), hydrotreated light : LC 50 inhalation / 6h (rat) : > 12 mg/l LD 50 oral (rat) : > 5000 mg/kg LD 50 skin (Rabbit) : 3160 mg/kg Titanium dioxide : LC 50 inhalation / 4h (rat) : > 3.56 mg/l LD 50 oral (Rat) : > 10000 mg/kg LD 50 skin (Rabbit) : > 10000 mg/kg (published data) : Causes skin irritation. : Based on available data, the classification criteria are not met. : No sensitizing effect reported : Titanium dioxide (powder) is listed as being potentially carcinogenic (group 2B) by the CIRC, based on studies on animals However, studies on human epidemiology do not suggest links between the occupational exposure to titanium dioxide and the risk of cancer : No additional information available : No additional information available : May cause drowsiness or dizziness. SOCIETE BIC 14, Rue Jeanne d'Asnières 92611 CLICHY FRANCE Page : 7 / 9 MATERIAL SAFETY DATA SHEET Version : 1 Date : 11 / 7 / 2012 Supersedes : 0 / 0 / 0 Tipp-ex® Shake’n Choose Correction pen BIC SECTION 11TOXICOLOGICAL INFORMATION (continued) STOT - repeated exposure Aspiration hazard : Based on available data, the classification criteria are not met. : Based on available data, the classification criteria are not met. SECTION 12 ECOLOGICAL INFORMATION 12.1. Toxicity 12.2. Persistence and degradability 12.3. Bioaccumulative potential 12.4. Mobility in soil 12.5. Results of PBT and vPvB assessment 12.6. Other adverse effects : Toxic to aquatic life with long lasting effects. Naphtha (petroleum), light alkylate : LC 50 (Fish : Pimephales promelas) / 96 h : 8.3 mg/l Naphtha (petroleum), hydrotreated light : EC 50 (crustacean) / 96 h : 2.6 mg/l (published data) : Mixture based on substances which are not readily biodegradable : No information available : No information available : No information available : No information available SECTION 13 DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods WASTE FROM PRODUCT Prohibition : Destruction/Disposal CONTAMINATED PACKAGING Destruction/disposal NOTE : Discharging waste into rivers and drains is prohibited : Dispose of in accordance with relevant local regulations : Destroy at an authorised site : The user's attention is drawn to the possible existence of specific European, national or local regulations regarding disposal SECTION 14 TRANSPORT INFORMATION : 14.1. UN number : 14.2. UN proper shipping name : 14.3. Transport hazard class(es) : 14.4. Packing group : 14.5. Environmental hazards : 14.6. Special precautions for user 14.7. Transport in bulk according to : Annex II of MARPOL73/78 and the IBC Code : NOTE 1139 COATING SOLUTION 3 I Additional marking : "Environmentally hazardous substance" No information available No information available The above regulatory prescriptions are those valid on the date of publication of this sheet. Given the possible evolution of transport regulations for hazardous materials, in SOCIETE BIC 14, Rue Jeanne d'Asnières 92611 CLICHY FRANCE Page : 8 / 9 MATERIAL SAFETY DATA SHEET Version : 1 Date : 11 / 7 / 2012 Supersedes : 0 / 0 / 0 Tipp-ex® Shake’n Choose Correction pen BIC SECTION 14 TRANSPORT INFORMATION (continued) case the date of issue is older than 12 months, compared to the current one, it would be advisable to check their validity with your commercial agency Packages from older stocks can especially have the UN number 1993 (due to the older classification) SECTION 15 REGULATORY INFORMATION : France : Occupational diseases (table(s) n° 84) 15.1. Safety, health and environmental regulations/legislation Germany : Water hazard class (WGK) : 2 specific for the substance or mixture : Not realized 15.2. Chemical Safety Assessment SECTION 16 OTHER INFORMATION R phrases text of § 2&3 H phrases text of § 2&3 Restrictions on use Bibliography references Safety data sheet established by : R11 : Highly flammable. R38 : Irritating to skin. R51/53 : Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment. R65 : Harmful : may cause lung damage if swallowed. R67 : Vapours may cause drowsiness and dizziness. : H225 : Highly flammable liquid and vapour H304 : May be fatal if swallowed and enters airways H315 : Causes skin irritation H336 : May cause drowsiness or dizziness H411 : Toxic to aquatic life with long lasting effects : This product must not be used for other applications that mentionned in §1. : Joint Research Centre (JRC) INRS (Institut National de Recherche et de Sécurité) IUCLID (International Uniform Chemical Information Data Base) RTECS (Registry of Toxic effects of Chemical Substances) MSDS of suppliers : LISAM SERVICES - TELEGIS 6 rue des Boucheries F-60400 NOYON www.reachelp.com Safety Made Easy with www.lisam.com This sheet complements the technical sheets but does not replace them. The information given is based on our knowledge of the product, at the time of publication. It is given in good faith. Besides, the attention of the user is drawn to the possible risk incurred by using the product for any other use than that for which it was intended. In no way does this exempt the user from knowing and applying all the regulations controlling his activity. The user alone will take on the responsibility for taking the precautions involved by the use of the product. The aim of all the mandatory regulations mentioned is just to help the user to fulfill his obligations regarding the use of hazardous products. This information must not be considered exhaustive. It does not exempt the user from ensuring that other obligations than those mentioned could apply, related to the storage and use of the product, this being his sole responsibility. SOCIETE BIC 14, Rue Jeanne d'Asnières 92611 CLICHY FRANCE Page : 9 / 9 MATERIAL SAFETY DATA SHEET Version : 1 Date : 11 / 7 / 2012 Supersedes : 0 / 0 / 0 Tipp-ex® Shake’n Choose Correction pen BIC End of document SOCIETE BIC 14, Rue Jeanne d'Asnières 92611 CLICHY FRANCE