PORTE CLIPS 2 VOIES 8mm PORTE CLIPS 2 VOIES 8mm

Transcription

PORTE CLIPS 2 VOIES 8mm PORTE CLIPS 2 VOIES 8mm
411-15746
Instruction sheets
10 Mars 11 , rev A
Recommandations Générales d’utilisation PC 2 VOIES 8mm ISOLEES
General instruction use for INSULATED 2w 8mm Connector
CAHIER DE PRECONISATIONS
INSTRUCTIONS FOR USE
PORTE CLIPS 2 VOIES 8mm ISOLEES
INSULATED 8mm 2 WAYS
CONNECTOR
Rédigé par :
P .CHARLES
Author by : le 10-03-11
Approuvé par :
Approved by :
Tyco Electronics France Sas
B.P. 30039, 95301 CERGY-PONTOISE Cedex
J. DAHER
©2002 Tyco Electronics Corporation
All International Rights Reserved
(Tous droits réservés)
Ce document est sujet à modifications. Contacter TYCO Electronics pour identifier la dernière révision et en obtenir une
copie. Personnel TYCO Electronics : consultez la base de données StarTEC.
This document can be modified. Contact TYCO Electronics to k now the last revision and to have a copy. TYCO
Electronics personnel, see the Startec database.
1 de 35
LOC F
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
SOMMAIRE / CONTENTS
1 SUIVI DES EVOLUTIONS DU DOCUMENT / DOCUMENT REVISIONS......................... 4
2 PRÉSENTATION DU PORTE-CLIP 8NG1+ A VOIES ISOLEES / PRESENTATION OF 8NG1+
RECEPTACLE HOUSING SEPARATED SEAL. .............................................................. 5
2.1
Porte clip / Receptacle housing ................................................................................ 5
2.2
Levier / lever............................................................................................................. 5
2.3
Joint interfacial / Interfacial seal................................................................................ 6
2.4
Verrou Secondaire / secondary lock......................................................................... 6
2.5
Capuchon de protection du linguet / Locking latch protection cap ............................ 6
2.6
Joint unifilaire et bouchon NG9K (x2) / Singlewire seal and plug NG9K (x2) ............ 6
2.7
Clip “8 mm NG1+” (3 gammes) / ” 8 mm NG1+” receptacle (3 ranges)..................... 6
2.8
Marquages Porte Clip / Receptacle housing marking ............................................... 7
2.9
Zones de prehension porte-clip / Housing holding device......................................... 8
3 REFERENCES DES PRODUITS / COMPONENT PART NUMBERS .............................. 8
3.1
Connecteurs assemblés / Assembled connectors .................................................... 8
3.2
Composants associés / Associated components...................................................... 8
4 LIVRAISON, CONDITIONNEMENT / DELIVERY,PACKAGING ..................................... 10
4.1
Type de conditionnement / Kind of packaging ........................................................ 10
4.2
Etiquette d’identification / Label identification ......................................................... 11
5 STOCKAGE, MANIPULATION ET RECONDITIONNEMENT / STORAGE, HANDLING AND
REPACKAGING ............................................................................................................. 12
6 MISE EN OEUVRE PRODUIT / PRODUCT IMPLEMENTATION.................................... 13
6.1
Sertissage des joints unifilaires / Singlewire seals crimping.................................... 13
6.2
Cablâge du porte clips / Receptacle housing cabling.............................................. 14
6.3
Fermeture verrou secondaire / Secondary lock closing .......................................... 15
6.4
Contrôle présence clips / Receptacle presence check............................................ 16
6.5
Test de conformité électrique / Electric conformity test........................................... 16
6.6
Insertion bouchon d’étanchéité / Plug insertion ...................................................... 16
6.7
Test de conformité de presence bouchons / Plug presence check ........................ 17
6.8
Enrubannage des fils / Wire wrapping .................................................................... 17
6.9
Rayon de courbure / Curvature radius.................................................................... 18
Rev A
2 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
7 ASSEMBLAGE PORTE-CLIPS / EMBASE / ASSEMBLY OF RECEPTACLE HOUSING AND
HEADERS....................................................................................................................... 20
7.1
Assemblage PC – contre partie / Housing-counter part assembly .......................... 20
7.2
Mise en place d’une goupille (OPTION) / add a staple (optionnal).......................... 21
8 DÉSACCOUPLEMENT / DISSASSEMBLING ................................................................ 23
8.1
Désaccouplement PC - embase / Housing – header dissassembling .................... 23
9 DÉVERROUILLAGE DU VERROU SECONDAIRE SUR PC / SECONDARY LOCK
RECEPTACLE HOUSING UNLOCKING ........................................................................ 25
10 DÉMONTAGE DES CLIPS / RECEPTACLE RELEASE : ............................................ 26
11 DÉMONTAGE DES BOUCHONS / PLUG RELEASE : ................................................ 27
12 ANNEXE 1 / APPENDIX 1 ............................................................................................ 29
13 ANNEXE 2 / APPENDIX 2 ............................................................................................ 30
14 ANNEXE 3 / APPENDIX 3 ............................................................................................ 31
15 ANNEXE 4 / APPENDIX 4 ............................................................................................ 32
16 ANNEXE 5 / APPENDIX 5 ............................................................................................ 33
17 ANNEXE 6 / APPENDIX 6 ............................................................................................ 34
18 ANNEXE 7 / APPENDIX 7 ............................................................................................ 35
18.1 Zone d’appui lors du bridage / Autorised clamp area.............................................. 35
18.2 Specification de contrôle électrique / Electric check spec. ...................................... 35
Rev A
3 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
1
411-15746
SUIVI DES EVOLUTIONS DU DOCUMENT / DOCUMENT REVISIONS
DATE
DATE
10 Jun 2011
Rev A
INDICE
REVISION
A
NATURE DE LA MODIFICATION
DESCRIPTION
Création / First Issue
4 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
2
411-15746
PRÉSENTATION DU PORTE-CLIP 8NG1+ A VOIES ISOLEES / PRESENTATION OF
8NG1+ RECEPTACLE HOUSING SEPARATED SEAL.
Boitier Porte
Capuchon / Cap
-clips /
Receptacle
housing
Joint interfacial /
Levier / Lever
Verrous
secondaires /
Secondary locks
Interfacial seal
2.1 PORTE CLIP / RECEPTACLE HOUSING
2.2 LEVIER / LEVER
Rev A
5 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
2.3 JOINT INTERFACIAL / INTERFACIAL SEAL
2.4 VERROU SECONDAIRE / SECONDARY LOCK
2.5 CAPUCHON DE PROTECTION DU LINGUET /
LOCKING LATCH PROTECTION CAP
2.6 JOINT UNIFILAIRE ET BOUCHON NG9K (X2) / SINGLEWIRE SEAL
AND PLUG NG9K (X2)
2.7 CLIP “8 MM NG1+” (3 GAMMES) / ” 8 MM NG1+” RECEPTACLE (3 RANGES)
Rev A
6 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
2.8 MARQUAGES PORTE CLIP / RECEPTACLE HOUSING MARKING
Repère d’alvéoles
Cavity ID
Dateurs semaine/année
Week / year date code
Identification fournisseur
Supplier identification
Repère d’empreinte
Mold Cavity ID
Identification moule
Mold ID
Identification matière
Material ID
Indice révision pièce
Part revision ID
Dateurs mois /année
Month / year date code
Repère d’empreinte
Mold Cavity ID
Identification moule
Mold ID
Identification matière
Material ID
Identification fournisseur
Supplier identification
Indice révision pièce
Part revision ID
Marquage jet d’encre
Jour - année assemblage –
PN pièces
Ink jet mark
Assembly day - assembly
year – Part PN
Rev A
Identification moule
Mold ID
Repère d’empreinte
Mold Cavity ID
Repère
d’empreinte de
1 a 4 emp
Mold Cavity ID,
1 to 4 cavities
7 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
2.9 ZONES DE PREHENSION PORTE-CLIP / HOUSING HOLDING DEVICE
Zone d’appui interdite lors de
l’accouplement sur embase ou PL.
Forbidden
land
area
when
connector fits.
Zones de préhension lors de
l’accouplement sur embase ou PL.
Holding area when connector fit
3
REFERENCES DES PRODUITS / COMPONENT PART NUMBERS
3.1 CONNECTEURS ASSEMBLÉS / ASSEMBLED CONNECTORS
Désignation
Description
REF TE
PN TE
1801398-1
1801398-2
1801398-3
1801398-4
1801398-5
PC 8mm 2V isolées
Insulated 2 Ways 8mm
Connector
Couleur
Color
Noir / Black
Bleu / Blue
Marron / Brown
Vert / Green
Violet / Purple
N° plan
Drawing Ref
1801398
3.2 COMPOSANTS ASSOCIÉS / ASSOCIATED COMPONENTS
Désignation
Description
Joint unifilaire NG9K
NG9K Seal
Bouchon NG9K
NG9K Plug
Clip 8 mm NG1+,
8 mm NG1+
Receptacle
Rev A
Section de
câble
Crimping range
2.5 à 5 mm²
2.5 to 5 mm²
6 à 7 mm²
6 to 7 mm²
10 mm²
10 mm²
2.5 à 4 mm²
3 to 6 mm²
5 à 6 mm²
3 to 6 mm²
7 à 10 mm²
7 to 10 mm²
REF TE
PN TE
Couleur Finition
Color - Finish
1544970-1
Marron / Brown
1544970-2
Bleu / Blue
1544970-3
Jaune / Yellow
1544970-4
Blanc / White
1544964-1
SnAg
1544964
1544965-1
SnAg
1544965
1544966-1
SnAg
1544966
N° plan
Drawing ref
1544970
8 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
CABLEUR
HARNESS MAKER
Rev A
9 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
4
411-15746
LIVRAISON, CONDITIONNEMENT / DELIVERY,PACKAGING
Nota : Le Porte clip est livré avec le levier et les verrous secondaires en position prémontée. Le capuchon est assemblé et ne peut-être retiré.
Note : The receptacle housing is delivery with the lever and the secondary lock open. The
cap is assembly and cannot be removed.
4.1 TYPE DE CONDITIONNEMENT / KIND OF PACKAGING
Désignation
Ref TYCO
Designation
TYCO Ref.
N°Carton
Box N°
GALIA
Vrac
Loose
Nb de
sac
Bag qty
Nb de
pièces
par sac
Qty of
part by
bag
Nb
pièces
par
carton
Poids
du
carton
Qty of
part by
box
Box
weight
1801398-1
-
-
300
12 kg
1801398-2
-
-
-
-
-
-
-
-
1801398-4
-
-
-
-
1801398-5
-
-
-
-
Joint unifilaire 1544970-1
NG9K
1544970-2
NG9K Seal
1544970-3
Bouchon
NG9K
1544970-4
NG9K Plug
1
8 000
8 000
9 kg
1
8 000
8 000
9 kg
1
8 000
8 000
9 kg
Oui
1
8 000
8 000
9 kg
1544964-1
Non
3
galettes
1 300 /
galette
3 900
10 kg
1544965-1
Non
3
galettes
1 300 /
galette
3 900
10 kg
1544966-1
Non
3
galettes
900 /
galette
1 800
10 kg
1544967-1
Non
2
galettes
1 100 /
galette
2 200
10 kg
1544968-1
Non
2
galettes
1 100 /
galette
2 200
10 kg
1544969-1
Non
2
galettes
850 /
galette
1 700
10 kg
PC 8mm 2V
isolées
Insulated 2
Ways 8mm
Connector
Clip 8 mm
NG1+,
8 mm NG1+
Receptacle
Languette 8
mm NG1+,
8 mm NG1+
tab
Rev A
1801398-3
A12
A9
A9
Oui
Oui
10 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
4.2 ETIQUETTE D’IDENTIFICATION / LABEL IDENTIFICATION
L’étiquette comporte les informations suivantes :
The tab had information as follow :
le PN TYCO Electronics
TYCO Electronics PN
la désignation du produit
Product definition
la date de conditionnement du produit
Product packaging date
la quantité de pièce
Quantity of parts in the box
le N° de lot (ordre de fabrication)
Batch N° (FO)
Rev A
11 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
5
411-15746
STOCKAGE, MANIPULATION ET RECONDITIONNEMENT / STORAGE, HANDLING AND
REPACKAGING
Stocker dans des lieux bien aérés où la température et l’humidité relative restent dans les
limites suivantes : 5° à 50°c ; 30% à 75 % HR.
To store in quite ventilated places where the temperature and the relative humidity remain
within the following limits : 5° to 50°c ; 30% to 75 % RH.
Stocker sans contact avec le sol, sur palette ou plate-forme, sur surface sèche et propre
jusqu'à ce que les emballages soient récupérés pour mise en production.
To store without contact with the floor, on pallet or platform, dry and clean surface until
packing are recover for setting in production.
Stocker les emballages à l’abri des précipitations d’eau et de l’influence directs des UV.
To store packing safe from water precipitations and the UV influence.
Stocker les emballages à l’abri des sources de chaleur et des zones subissant des fortes
variations de températures.
To store packing safe from heat source and high variations of temperatures zone.
Stocker à l’abri des variations rapides de températures ou d’hygrométrie pour éviter la
condensation à l’intérieur des emballages.
To store safe from the fast variations of temperatures or hygroscopy to avoid condensation
inside packing.
Stocker les emballages à l’abri de la poussière pour maintenir les composants propres.
To store packing safe from dust to maintain the components clean.
Conserver les emballages dans l’état de réception, sans défaire le ruban adhésif jusqu’à
utilisation.
To keep packing in the state of reception, do not open before used.
Reconditionner les emballages après prélèvement partiel dans celui-ci.
To recondition packing after partial taking away.
Ne pas marcher et ne pas poser d’objet lourd, sur les emballages.
Do not walk and do not put a heavy object, on packing.
Les emballages reçus, doivent être traités sur la base du First-in, First-out (FIFO).
Received packing, must be treated on the basis of First-in, First-out (FIFO)
Lorsque les emballages sont stockés en racks, placer les cartons les plus lourds en dessous,
les plus légers sur le dessus, afin de ne pas abimer les pièces.
When packing are stored in racks, place the heaviest box under and the lightest on the top,
in order to not spoil parts.
Une période (≈24 heures) d’équilibrage thermique est nécessaire avant câblage des
connecteurs.
One period (≈24 hours) of thermal balancing is necessary before wiring the connectors.
Rev A
12 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
6
411-15746
MISE EN OEUVRE PRODUIT / PRODUCT IMPLEMENTATION
6.1 SERTISSAGE DES JOINTS UNIFILAIRES / SINGLEWIRE SEALS CRIMPING
Les joints NG9K sont à sertir suivant les paramètres inscrits aux plans client.
Vérifier après sertissage que le joint n’est pas déchiré. La classe d’étanchéité de l’ensemble
est de 500mBar
The NG9K seals must be crimped following parameters described on customer drawings.
Please check after crimping operation that there is no alteration on the seal. The sealing test
pressure for the assembly connector is 500mB.
Joints unifilaire NG9K / NG9K single wire seals
Gammes
Ranges
2.5 à 5 mm²
2.5 to 5 mm²
6 à 7 mm²
6 to 7 mm²
10mm²
10mm²
Ø fil mini et maxi (Ir or B)
Mini and maxi Ø wire (IR or B)
2.65 - 3.9 mm
3.8 - 4.6mm
6 mm maxi
Ø fil mini et maxi (ID or C)
Mini and maxi Ø wire (ID or C)
2.7 - 3.7 mm
3.7 - 4.3 mm
6 mm maxi
Les joints tombés à terre devront être rebutes.
Seals fell down must be scrapped.
Rev A
13 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
6.2 CABLAGE DU PORTE CLIPS / RECEPTACLE HOUSING CABLING
Une fois les clips sertis sur les câbles, insérer les clips suivant le schéma ci-dessous :
Once the receptacles are crimped, insert inside the housing according to following picture :
Le Double verrouillage doit être ouvert
pour permettre l’insertion des clips sertis.
The secondary lock device must be in
open position to permit the receptacle
insertion
Clips réversibles à 180 °.
Reversible
180°receptacles
10N < F1 < 30N
Porte clip équipé de son contact
Housing with his female receptacle.
Rev A
14 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
6.3 FERMETURE VERROU SECONDAIRE / SECONDARY LOCK CLOSING
Une fois les clips sertis insérés, utiliser l’outil adapté (PN : 2-1579018-3) pour le verrouillage
des VS. Insérer la pointe cylindriques à travers le levier, et pousser jusqu’en butée comme
indiqué sur le schéma suivant :
Once the crimped receptacles inserted inside the housing, use the specific tool (PN 21579018-3) to close the SL. Put the tool through the lever and push on the secondary lock
according to following picture:
20N < F2 < 50N
On the both side
Butée / limit stop
Butée / limit stop
Outil en appui contre le VS
Tool in front of the SL
VS verrouillé
SL locked
Si un des clips n’est pas correctement inséré, le verrou secondaire ne pourra s’encliqueter
en position et interdira l’accouplement PC/embase.
If almost one receptacle is not correctly inserted inside the housing, the secondary lock
device could not be closed in good position and then, the assembly with the header could not
be possible.
Nota : Plan de l’outil de démontage des clips, voir annexe 2
Note : Drawing of Receptacle removal tool, see appendix 2
Rev A
15 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
6.4 CONTROLE PRESENCE CLIPS / RECEPTACLE PRESENCE CHECK
La présence des clips dans le connecteur est contrôlée suivant la préconisation de contrôle :
annexe 7.
The receptacle terminal attends is checked following the control specification: appendix 7
Le double verrouillage doit être activé. Dans le cas contraire, Il sera impossible de verrouiller le
connecteur sur le dispositif de test électrique.
The secondary lock must be close. If not, it will be impossible to fit the connector on the electric
work holding devices
6.5 TEST DE CONFORMITE ELECTRIQUE / ELECTRIC CONFORMITY TEST
Test électrique sur porte-clip suivant Préconisation de contrôle : annexe 7
Electrical test of receptacle housing in accordance with control specification: appendix 7
Le double verrouillage doit être activé. Dans le cas contraire, Il sera impossible de verrouiller le
connecteur sur le dispositif de test électrique.
The secondary lock must be close. If not, it will be impossible to fit the connector on the electric
work holding devices.
6.6 INSERTION BOUCHON D’ÉTANCHÉITÉ / PLUG INSERTION
Dans le cas d’une application en 1 seule voie, obturer l’alvéole non utilisée à l’aide d’un
bouchon d’étanchéité .
In case of only 1-way application, close the unused cavity with a seal plug.
Insérer le bouchon manuellement, puis l’enfoncer avec l’outil jusqu’en butée sur l’alvéole.
L’extrémité du bouchon dépasse du fût de l’alvéole de 2 mm. Utiliser l’outil ref 7-1579008-9.
Insert the plug manually, and then push it with the tool until the top of the cavity. It gets out of the
cavity from 2mm
To use the specific tool ref 7-1579008-9.
(2mm± 1)
Nota : Plan de l’outil de démontage des clips, voir annexe 4
Note : Drawing of Receptacle removal tool, see appendix 4
Rev A
16 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
6.7 TEST DE CONFORMITE DE PRESENCE BOUCHONS / PLUG PRESENCE CHECK
La classe d’étanchéité du produit est A2 pour 500mbars. Le bouchon, une fois inséré doit tenir
cette pression. Ce contrôle permettra de vérifier entre autre la présence du bouchon.
The sealing request is A2 for 500mbrs. The plug, in the cavity must hold this pressure. The plug
attendance will be check by this test.
6.8 ENRUBANNAGE DES FILS / WIRE WRAPPING
Les faisceaux doivent être enrubannés afin d’éviter les problèmes dus aux vibrations et aux
frottements qui peuvent occasionner un mauvais fonctionnement du câblage, des courts-circuits ou
des ruptures de continuité électrique.
The beams must be tie to avoid the problems due to the vibrations and frictions which can cause, a
bad operation of wiring, a short-circuit or the electric continuity ruptures.
Lors de cette opération, ne pas débuter l’enrubannage au ras du boitier mais laisser un minimum
de 30mm de fils libres permettant d’assurer un jeu de contact dans le boitier et garantissant une
extraction aisée si nécessaire.
At the time of this operation, do not begin the spiral wrapping at the end of the connector. Keep a
minimum of 30mm free wire to ensure a gap of contact in the housing and guaranteeing an easy
extraction if necessary.
Fils
Wires
Face avant du
connecteur
Front of face of
connector
Enrubannage
Wrapping
Connecteur
Connector
30 mm
Mini
Enrubannage du faisceau
Beams wrapping
Rev A
17 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
6.9 RAYON DE COURBURE / CURVATURE RADIUS
Préconisation d’un rayon minimum de courbure du fil à l’arrière du porte-clips tout en gardant une
partie rectiligne de celui-ci (de 5mm mini).
We recommend keeping the wire curvature to a minimum at the back of the clip housing.
Furthermore, the first part of the wire (at least 5mm from the outlet) must remain straight.
Rev A
Section du fil
Wire section
Rayon mini
Min. radius
3² à (to) 6²
5mm
7²
10mm
10²
15mm
18 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
EN LIGNE
END USER
Rev A
19 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
7
411-15746
ASSEMBLAGE PORTE-CLIPS / EMBASE / ASSEMBLY OF RECEPTACLE HOUSING
AND HEADERS.
7.1 ASSEMBLAGE PC – CONTRE PARTIE / HOUSING-COUNTER PART ASSEMBLY
Avant assemblage, vérifier que les verrous secondaires sont bien en position verrouillée. Si le
verrou secondaire du PC n’est pas correctement positionné, l’assemblage sera impossible. Le
levier doit également être en position pré-monté.
Before assembly, check that the secondary locks are correctly positioned. If only once of the
receptacle SL is not locked, the assembly will be not possible. The lever must be in pre-assembly
position.
Positionner en butée, le Porte clip dans l’embase et appliquer un effort sur le levier suivant F5.
L’effort de connexion doit être inférieur à 60 N.
To position in limit stop the receptacle housing inside the header and slide the lever following F5.
The mating force must be less than 60N
Le capuchon ne gène pas la rotation du levier
The cap position isn’t in the way of the lever.
Le levier est en position pré-monté.
The lever is in pre-assembled position.
Le Double verrouillage doit être fermé pour
permettre l’insertion du PC dans l’embase.
The secondary lock device must be in
locking position to permit the housing
insertion
CLIC !
Levier verrouillé
Locked lever
F5 < 60 N
Rev A
20 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
7.2 MISE EN PLACE D’UNE GOUPILLE (OPTION) / ADD A STAPLE (OPTIONNAL)
La présence du capuchon assemblé sur le porte clips, interdit l’ajout d’une goupille.
The cap assembly on the receptacle housing, prevent the staple setting up.
Passage goupille.
Staple hold
Capuchon en position.
Assembly cap
La goupille ne peut pas se loger derrière le linguet d’accroche du PC
The staple can not be place behind the locking device
Rev A
21 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
REPARATION / SAV
REPAIRS
Rev A
22 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
8
411-15746
DESACCOUPLEMENT / DISSASSEMBLING
8.1 DÉSACCOUPLEMENT PC - EMBASE / HOUSING – HEADER DISSASSEMBLING
Manuellement / By hand
Le désaccouplement du porte clip de l’embase s’effectue en appuyant sur le linguet d’accroche
afin de libérer le levier. Basculer le levier à 90° vers l’avant jusqu’en butée complète (F8). Puis
séparer le Porte clip de l’embase suivant F9.
The receptacle housing extraction from header, is mad when you push on the locking device to
free up the lever. Switch over, the lever, from 90° on the front of the receptacle housing until it
comes in stop (F8). Then separate le two part (F9).
F8
F9
Rev A
23 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
L’aide d’un outil / With handling tool
L’utilisation de l’outil réf. 3-1579018-9 spécifique prévu à cet effet pour déverrouiller le levier, est
possible grâce à l’ouverture prévue sur la face avant du levier.
It is possible to use the specific tool ref 3 -1579018-9 to unlock the lever. An opening is realising on
the front side of the lever.
Insérer l’outil dans le
passage du levier, à plat
contre le linguet.
Insert the flat side of the tool in the
lever opening.
Faire tourner d’un quart de
tour
l’outil contre le
linguet. Le levier est
déverrouillé. Basculer le
levier vers l’avant pour
extraire le connecteur
Le
linguet
libère
l’accroche du levier.
The latch free up the lever
Turn of ¼ the tool against
the latch. The lever is
open. Slide the lever in
front to disconnect the
connector.
Nota : Plan de l’outil d’ouverture du verrou secondaire, voir annexe 6
Note : Drawing of secondary lock open tool, see appendix 6
Rev A
24 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
9
411-15746
DEVERROUILLAGE DU VERROU SECONDAIRE SUR PC / SECONDARY LOCK
RECEPTACLE HOUSING UNLOCKING
Pour le déverrouillage du verrou secondaire, utiliser l’outil réf. 2-1579018-2 spécifique prévu à cet
effet. Glisser l’outil dans le porte clip, il est guidé par les alvéoles
To unlock the secondary lock, use the specific tool ref 2-1579018-2.
Slide the tool in the receptacle housing. The tool is positioned by the cavities
10N < F10 < 30N
2 lames repoussent les verrous secondaires de
leur position verrouillée.
2 blades extract the secondary lock from
his lock position.
Pousser linéairement l’outil dans le porte-clips jusqu'à ce qu’il bute contre la face avant du PC.
Push linear full, the tool under the lock until it stops on the housing.
Le verrou est ouvert.
The lock is opened
L’outil est en butée
contre le porte clip.
The tool is stopped by
the housing.
Nota : Plan de l’outil d’ouverture du verrou secondaire, voir annexe 3
Note : Drawing of secondary lock open tool, see appendix 3
Rev A
25 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
10 DEMONTAGE DES CLIPS / RECEPTACLE RELEASE :
Pour démonter les clips, s’assurer que le verrou secondaire est bien en position pré-montée.
To remove the clips, make sure that the secondary latch is properly in pre-mounted position.
Mode opératoire / Procedure :
- Introduire l’outil ref : 5-1579008-9 dans l’alvéole par l’avant du porte-clips, comme indiqué
dans le schéma, jusqu’à ce qu’il vienne en buté sur les deux linguets primaires.
- Introduce the tool ref: 5-1579008-9 into the cavity by the front of the clip housing, like explain
by the schema, until it comes to a stop on the primary latches.
Sens d’insertion de l’outil de démontage
dans l’alvéole
Direction of tool insertion into the cavity
F11
- Insérer l’outil suivant F11 afin de dégager les linguets primaires des fenêtres de verrouillage
du clip. Maintenir l’outil et le porte clip d’une main.
- To insert the tool according to F11 in order to give off the primary latches from the clip locking
windows. To maintain the tool and the housing of one hand.
Linguets primaires dégagés /
Primary latch released
Sens d’extraction du clip
Direction of clip extraction
F11
- Un fois les linguets primaires soulevés, tirer sur le câble pour extraire le clip.
- Once the primary latches raised, pull on the cable to remove the clip.
Nota : Plan de l’outil de démontage des clips, voir annexe 1
Note : Drawing of Receptacle removal tool, see appendix 1
Rev A
26 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
11 DEMONTAGE DES BOUCHONS / PLUG RELEASE :
Introduire l’outil ref : 2-1579018-4 dans le trou, au centre du bouchon, comme indiqué dans le
schéma.
- Introduce the tool ref: 2-1579018-4 into the hole in the middle of the plug, like explain by the
schema.
Sens d’insertion de l’outil de démontage
dans le bouchon
Direction of tool insertion into the plug
Crocheter le bouchon à l’aide de l’outil sans le déchirer, attention à ne pas endommager
l’alvéole.
To catch the plug with the tool. Carful to not damage the plug or the cavity
- Tout en maintenant le bouchon avec l’outil l’extraire de l’alvéole. Un bouchon démonté sera
aussitôt rebuté.
- While maintaining the plug with the tool, remove it out of the cavity. The removing plug must
be scrap.
Sens d’extraction du bouchon
Direction of plug extraction
Nota : Plan de l’outil de démontage des bouchons, voir annexe 5
Note : Drawing of plug removal tool, see appendix 5
Rev A
27 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
ANNEXES
APPENDIX
Rev A
28 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
12 ANNEXE 1 / APPENDIX 1
Outil de démontage de clip 8MM NG1+ (PN 5-1579008-9)
Removal tool for 8MM NG1+ receptacle terminal ( PN 5-1579008-9)
Rev A
29 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
13 ANNEXE 2 / APPENDIX 2
Outil de verrouillage du verrou secondaire du PC2v isolées (PN : 2-1579018-3)
Locking tool for secondary lock of insulated 2w rcpt hsg (PN : 2-1579018-3)
Rev A
30 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
14 ANNEXE 3 / APPENDIX 3
Outil d’aide à l’ouverture du double verrouillage du porte clip 2v isolées (PN 2-1579018-2)
Help removal tool for secondary lock of insulated 2w rcpt housing (PN 2-1579018-2 )
Rev A
31 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
15 ANNEXE 4 / APPENDIX 4
Outil d’aide à la mise en place du bouchon (alvéole NG1+) (PN 7-1579008-9)
Help removal tool for seal plug (cavity NG1+) (PN 7-1579008-9)
Rev A
32 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
16 ANNEXE 5 / APPENDIX 5
Outil de démontage des bouchons (PN : 2-1579018-4)
Help removal tool for plug (PN : 2-1579018-4)
Rev A
33 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
17 ANNEXE 6 / APPENDIX 6
Outil de déverrouillage du levier (PN : 3-1579018-9)
Help removal tool unlocking the lever (PN : 3-1579018-9)
Rev A
34 de 35
Recommandations Générales d’utilisation
PC 8mm 2 VOIES ISOLEES
General instruction use for INSULATED 2w 8mm Connector
411-15746
18 ANNEXE 7 / APPENDIX 7
18.1 ZONE D’APPUI LORS DU BRIDAGE / AUTORISED CLAMP AREA
Zone de bridage sur montage
de test électrique.
Restraint area on electric test
work holding device.
L’intégration du porte clip dans les montages de test doit impérativement
respecter le plan d’interface N° 1801382.
The work holding devices design must respected the interface drawing N° 1544681.
18.2 SPECIFICATION DE CONTROLE ELECTRIQUE / ELECTRIC CHECK SPEC.
Course et tarage de la pointe de teste / Test pin travelling and adjustment :
Course mini des touches de contrôle = 5mm / Minimum test pin travelling is 5mm.
Effort maxi sur le clip 50N / Maxi effort on the receptacle is 50N
Surface de bridage
Pour contrôle électrique
Clamping face for
electric check.
Face d’appui référenciel
Pour contrôle électrique
Reference apply face
for electric check.
Dépassement de la pointe
de teste à vide
Test pin position
with unlocked receptacle
Rev A
35 de 35

Documents pareils

108-15347

108-15347 Tyco Electronics France Sas ©2002 Tyco Electronics Corporation B.P. 39, 95301 CERGY-PONTOISE Cedex All International Rights Reserved (Tous droits réservés) Ce document est sujet à modifications. Co...

Plus en détail