EXPOSURE LIMITS TABLE
Transcription
EXPOSURE LIMITS TABLE
MATERIAL SAFETY DATA SHEET Page 1 of 4 1 - MATERIAL IDENTIFICATION Material Name: Supplier / Manufacturer Identification: Emergency Telephone Number: Qualisorb 628 and 715 EaglePicher Filtration & Minerals, Inc. 9785 Gateway Drive, Suite 1000 Reno, Nevada 89521 Phone Number: (775) 824-7600 (775) 824-7600 2 - COMPOSITION / INFORMATION ON INGREDIENTS Chemical Name Wt % Diatomaceous earth calcined 100% Crystalline silica, Quartz < 1% Crystalline silica, Cristobalite < 1% CAS # 91053-39-3 14808-60-7 14464-46-1 3 - HAZARDS IDENTIFICATION This product consists of calcined diatomaceous earth and small quantities of crystalline silica (less than 1%). Prolonged breathing of dust containing crystalline silica may cause lung damage, and on rare occasions be fatal. Avoid breathing dust (see Section 11 for additional information). 4 - FIRST AID MEASURES Remove to fresh air. 4.1 Inhalation: Short-term exposure not considered harmful. Drink water to reduce bulk and 4.2 Ingestion: drying effects. Wash with generous quantities of water. Consult physician if irritation 4.3 Eyes: persists. None necessary. If dryness occurs, use moisture renewing lotions. 4.4 Skin: 5 - FIRE FIGHTING MEASURES 5.1 Flashpoint and Method: 5.2 Flammable Limits: 5.3 Autoignition Temperature: 5.4 Flammable Class: 5.5 Flame Propagation or burning rate of solids: 5.6 General Hazard: 5.7 Extinguishing Media: 5.8 Hazardous Combustion Products: 5.9 Fire Fighting Procedures: 5.10 Fire Fighting Equipment: 5.11 Sensitive to Static Discharge: 5.12 Sensitivity to Impact: Not applicable Not applicable Not applicable Non-Flammable Non-Flammable Non-Flammable Not applicable Non-Flammable Not applicable Non-Flammable Not applicable None Not applicable Not applicable Not applicable Not applicable Not applicable Non-Flammable Non-Flammable Non-Flammable Non-Flammable Non-Flammable Non-Flammable Non-Flammable Qualisorb 628 and 715 Page 2 of 4 6 - ACCIDENTIAL RELEASE MEASURES Diatomaceous earth is a non-toxic, non-biodegradable 6.1 Environmental Precautions: mineral. Waste generated from this product would only be considered hazardous when mixed with a substance that would be considered hazardous. No special procedures necessary 6.2 General Procedures: No special procedures necessary 6.3 Release Notes: 7 - HANDLING & STORAGE 7.1 Handling: 7.2 Storage: Use appropriate personal protective equipment as specified in Section 8. Handle and use in a manner consistent with good industrial practice. Store unopened containers in a dry place. 8 - EXPOSURE CONTROLS/ PERSONAL PROTECTION Control dust to within the ACGIH-TLV with local ventilation. 8.1 Engineering Controls: EXPOSURE LIMITS TABLE 8.2 Occupational exposure limits: ACGIH-TLV Quartz mg/m3 0.10 Cristobalite mg/m3 0.05 8.3 Personal Protective Equipment: Respiratory: Respirators fitted with filters certified to NIOSH (US) standard 42CFR84 under series N95 should be worn when airborne dust is present. Skin: Not normally necessary Eyes & Face: Not normally necessary 9 - PHYSICAL AND CHEMICAL PROPERTIES Solid 9.1 Physical State: Odorless 9.2 Odor: Buff to off-white granular 9.3 Appearance: 7 9.4 pH (10% slurry): Buff to off-white 9.5 Color: Not applicable 9.6 Boiling point: Not applicable 9.7 Melting point: Not applicable 9.8 Oxidizing properties: Not applicable 9.9 Vapor pressure: 2.2 (specific gravity) 9.10 Density: < 2% 9.11 Solubility in water: Not applicable 9.12 Coefficient oil/water: None 9.13 Other data: Qualisorb 628 and 715 10 - STABILITY and REACTIVITY 10.1 Conditions to avoid: 10.2 Stability: 10.3 Hazardous decomposition products: 10.4 Other considerations: Page 3 of 4 Hydrofluoric acid Stable Not applicable None 11 - TOXICOLOGICAL INFORMATION Not available 11.1 Dermal LD50: Not available 11.2 Oral LD50: Not available 11.3 Inhalation LC50: May cause significant irritation to the eye 11.4 Eye effects: May cause dryness 11.5 Skin effects: Not available 11.6 Sensitization: 11.7 Chronic: This product contains small quantities of crystalline silica, which is a known cause of silicosis, a progressive, sometimes fatal lung disease. In a 1997 monograph (Volume 68, “Silica, Some Silicates, Coal Dust and Para-aramid Fibrils”), the International Agency for Research on cancer (IARC) has classified “inhaled crystalline silica from occupational sources” in Group 1 as a substance “carcinogenic to humans”. In making the overall evaluation, the IARC Working Group noted that carcinogenicity in humans was not detected in all industrial circumstances studied. A 1992 study by University of Washington researchers of certain diatomite workers reported an excess risk of nonmalignant respiratory disease (NMRD), Standardized Mortality Ratio (SMR) of 2.59 and an excess risk of lung cancer SMR=1.43. A 1996 follow up reported reduced risk with a SMR=2.01 for NMRD and a SMR=1.29 for lung cancer. As noted in the 1992 study and supported in the follow up, relatively intense exposures to crystalline silica that occurred before the 1950’s were probably the most important contributors to the excesses in NMRD and lung cancer. A more detailed report discussing the IARC classification and the diatomite worker studies are available on request. 12 - ECOLOGICAL INFORMATION 12.1 Environmental Data: Insoluble mineral product. Will not have adverse impact on waterways. 12.2 Ecotoxicological information: Not applicable 12.3 Chemical fate information: Not applicable 13 DISPOSAL CONSIDERATIONS 13.2 Product disposal: Use solid waste disposal common to landfill operations. Not considered hazardous waste. Avoid creating dust. 13.3 Empty container: Avoid creating dust. 13.4 General comments: None 13.1 Disposal method: Qualisorb 628 and 715 Page 4 of 4 14 - TRANSPORT INFORMATION 14.1 DOT (Department of Transportation): A. Proper shipping name Not restricted by DOT B. Technical name Diatomaceous earth C. Label Use product identifier (trade name) with Technical name below. 14.2 Canada Transport of Dangerous Goods: A. Proper shipping name Not restricted B. Technical name Diatomaceous earth C. Label Use product identifier (trade name) with Technical name below. 15 – REGULATORY INFORMATION 15.1 WHMIS Hazard Symbol & Classification 15.2 Canada – Ingredient Disclosure List - Class D, Division 2, Subdivision A - Chronic toxic effect by inhalation - WHMIS toxic and WHMIS controlled This product does not have any ingredient(s) on the Ingredient Disclosure List. 15.3 Canada – Environmental Protection Act- Product listed on Domestic Substance List. 15.4 This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all of the information required by the Controlled Products Regulations. 16 – OTHER INFORMATION NFPA CODES: Fire: 0 Health: 1 Reactivity: 0 HMIS CODES: Fire: 0 Health: * Reactivity: 0 Protection: E * Refer to data on Material Safety Data Sheet Preparation Date of MSDS Prepared by: Peter Lenz – Director, Research & Development Telephone Number: (775) 824-7600 Date: July 1, 2004 FICHE SIGNALÉTIQUE Page 5 de 4 1 - IDENTIFICATION DU PRODUIT Appellation commerciale : Coordonnées du fournisseur / fabricant : Numéro de téléphone d’urgence : QUALISORB 628 et 715 EaglePicher Filtration & Minerals, Inc. 9785 Gateway Drive, Suite 1000 Reno, Nevada 89521 Téléphone : (775) 824-7600 (775) 824-7600 2 - COMPOSITION / INFORMATION SUR LES INGRÉDIENTS Appellation chimique Poids % Terre à diatomées, calcinée 100 % Silice cristalline, quartz <1% Silice cristalline, cristobalite <1% CAS No 91053-39-3 14808-60-7 14464-46-1 3 - IDENTIFICATION DES DANGERS Ce produit contient de la terre à diatomées et de petites quantités de silice cristalline (moins de 1 %). L’inhalation prolongée de poussière contenant de la silice cristalline peut entraîner des dommages pulmonaires et dans de rares cas, entraîner la mort. (Pour de plus amples renseignements, voir la partie 11). 4 - PREMIERS SOINS Amener la personne incommodée à l’air frais. 4.1 Inhalation : L’exposition de courte durée n’est pas considérée dangereuse – boire de 4.2 Ingestion : l’eau pour réduire les effets généraux et l’assèchement. Rincer à grande eau – consulter un médecin si l’irritation persiste. 4.3 Yeux : Aucune mesure nécessaire. Utiliser une lotion hydratante en cas 4.4 Peau : d’assèchement de la peau. 5 - MESURES ANTI-INCENDIE 5.1 Point d’éclair et méthode : 5.2 Limites d’inflammabilité : 5.3 Température d’autocombustion : 5.4 Classe d’inflammabilité : 5.5 Propagation des flammes ou rapidité de combustion des solides : 5.6 Dangers particuliers : 5.7 Moyens d’extinction : 5.8 Produits de combustion dangereux : 5.9 Procédures anti-incendie : 5.10 Équipement anti-incendie : 5.11 Sensibilité à une décharge statique : 5.12 Sensibilité à l’impact mécanique : Sans objet Sans objet Sans objet Sans objet Sans objet Ininflammable Ininflammable Ininflammable Ininflammable Ininflammable Sans objet Néant Sans objet Sans objet Sans objet Sans objet Sans objet Ininflammable Ininflammable Ininflammable Ininflammable Ininflammable Ininflammable Ininflammable QUALISORB 628 ET 715 Page 2 de 4 6 - MESURES EN CAS DE FUITE ACCIDENTELLE 6.1 Précautions environnementales : La terre à diatomées est un minéral non toxique et non biodégradable. Les déchets générés à partir de ce produit ne peuvent être considérés dangereux que s’ils sont mélangés avec une substance réputée dangereuse. Non nécessaires 6.2 Procédures générales : Non nécessaires 6.3 Avis de déversement : 7 - MANUTENTION ET ENTREPOSAGE Utiliser l’équipement de protection personnel approprié, 7.1 Manutention : conformément aux directives de la partie 8. Manipuler et utiliser le produit conformément aux bonnes pratiques industrielles. Entreposer les contenants scellés dans un endroit sec. 7.2 Entreposage : 8 - CONTRÔLES D’EXPOSITION / PROTECTION PERSONNELLE À l’aide d’un système de ventilation locale, maîtriser la 8.1 Installations techniques : concentration de poussières afin qu’elle reste inférieure à la VLE de l’ACGIH. TABLEAU DES LIMITES D’EXPOSITION 8.2 Limites d’exposition : ACGIH-VLE Quartz mg/m3 Cristobalite mg/m3 0,10 0,05 8.3 Équipement de protection personnel : Respiratoire : Un appareil respiratoire équipé d’un filtre certifié conforme à la norme NIOSH (USA) 42CFR84, série N95, doit être utilisé lorsque des poussières sont présentes dans l’air. Peau : Normalement pas nécessaire Yeux et visage : Normalement pas nécessaire 9 - CARACTÉRISTIQUES PHYSIQUES ET CHIMIQUES Solide 9.1 État physique : Inodore 9.2 Odeur : Granulaire, chamois à blanc cassé 9.3 Apparence : 7 9.4 pH (10 % de boue liquide) : Chamois à blanc cassé 9.5 Couleur : Sans objet 9.6 Point d’ébullition : Sans objet 9.7 Point de fusion : Sans objet 9.8 Propriétés d’oxydation : Sans objet 9.9 Pression de vapeur : 2,2 (poids spécifique) 9.10 Densité : <2% 9.11 Solubilité dans l’eau : 9.12 Coefficient de partage huile / eau : Sans objet Néant 9.13 Autres données : QUALISORB 628 et 715 10 - STABILITÉ et RÉACTIVITÉ 10.1 Conditions à éviter : 10.2 Stabilité : 10.3 Produits de dÉcomposition nocifs : 10.4 Autres données : Page 3 de 4 Acide fluorhydrique Stable Sans objet Néant 11 - INFORMATION TOXICOLOGIQUES Non accessible 11.1 LD50 cutané : Non accessible 11.2 LD50 oral : Non accessible 11.3 LC50 inhalé : Peut provoquer une importante irritation des yeux 11.4 Effets sur la vue : Peut provoquer l’assèchement de la peau 11.5 Effets cutanés : Non accessible 11.6 Sensibilisation : 11.7 Effet chronique : Ce produit renferme de petites quantités de silice cristalline, qui est une cause de silicose avérée, une maladie pulmonaire progressive, parfois mortelle. Dans une mammographie effectuée en 1997 (Volume 68, Silica, Some Silicates, Coal Dust and Para-aramid Fibrils – La silice, certains silicates, la poussière de charbon et les fibrilles paraaramides), le Centre international de recherche sur le cancer (CIRC) a classifié « la silice cristalline inhalée dans un milieu occupationnel » dans le Groupe 1 comme substance « cancérogène pour les humains ». Dans son évaluation globale, le groupe de travail du CIRC a noté que la cancérogénicité n’était pas décelée dans toutes les industries étudiées. Une étude menée par les chercheurs de l’Université de Washington sur des travailleurs du domaine des produits de terre à diatomées a indiqué un accroissement du risque de maladie pulmonaire bénigne (MPB), un ratio standardisé de mortalité (RSM) de 2,59 et une hausse du risque de cancer des poumons (RSM=1,43). Un suivi effectué en 1996 a démontré une baisse de risque avec un RSM de 2,01 pour MPB et un RSM de 1,29 pur le cancer des poumons. Comme cela est indiqué dans l’étude de 1992 et corroboré par le suivi, les expositions intensives à la silice cristalline survenues avant 1950 ont probablement été l’un des facteurs les plus importants ayant contribué à la hausse de MPB et de cancer des poumons. Sur demande, des rapports plus détaillés sur la classification et l’étude menée sur les travailleurs du domaine des produits de terre à diatomées du CIRC sont accessibles. 4 5 - INFORMATION ÉCOLOGIQUE 12.1 Données environnementales : Produit minéral insoluble. N’a aucun effet nocif sur les cours d’eau. 12.2 Information écotoxicologique : Sans objet 12.3 Information sur l’évolution chimique : Sans objet CONSIDÉRATIONS POUR L’ÉLIMINATION DES DÉCHETS Se débarrasser des déchets solides de la manière 13.1 Méthode d’élimination : habituelle dans les dépotoirs. N’est pas considéré comme un déchet dangereux. Éviter de créer de la poussière 13.2 Élimination des produits : 13.3 Contenant vide : Éviter de créer de la poussière. 13.4 Commentaires généraux : Néant QUALISORB 628 et 715 Page 4 de 4 14 - INFORMATION SUR LE TRANSPORT 14.1 DOT (département des Transports des USA) A. Nom pour le transport Non restreint par le DOT B. Nom technique Terre à diatomées C. Étiquette Utiliser un identificateur de produit (nom de marque) avec le nom technique en-dessous). 14.2 Canada Transport de Produits Dangereux : A. Nom pour le transport Non restreint B. Nom technique Terre à diatomées C. Étiquette Utiliser un indicateur de produit (nom de marque) avec le nom technique en-dessous. 15 – INFORMATION RÉGLEMENTAIRE 15.1 - Symbolisation et classification des - Classe D, Division 2, Subdivision A Effet toxique chronique en cas d’inhalation Matière très toxique, contrôlée par le SIMDUT 15.2 Canada – Liste de divulgation des ingrédients : Ce produit ne contient aucun élément figurant sur la liste de divulgation des ingrédients du SIMDUT. 15.3 Canada – Loi sur la protection de l’environnement : - Produit inscrit sur la liste intérieure de substances. – INFORMATIONS ADDITIONNELLES CODES NFPA : Feu : 0 Santé : 1 Réactivité : 0 CODES HMIS : Feu : 0 Santé : * Réactivité : 0 Protection : E * Consulter les données de la fiche signalétique DATE DE PRÉPARATION DE LA FICHE SIGNALÉTIQUE Préparée par : Peter Lenz, Directeur – Recherche et développement Numéro de téléphone : (775) 824-7600 Date : 1er juillet 2004